Cornelius CM600 Instrukcja Właściciela

Installation/Owner’s ManualICE MAKER(WM600 AND CM600)IMPORTANT:TO THE INSTALLER.It is the responsibility of the Installer toensure that the water supp

7 6304600822. Check the drain tubes for clogs and ”aged” tubes. Replace if tubes are stained or brittle.FIGURE 2. AUGER ASSEMBLY3. Check for signs of

8630460082TO REPLACE WATER LEVEL CONTROL1. Shut off the water supply. Shut off the main power switch or unplug the Ice Maker from electrical outlet.2.

9 630460082REFRIGERATION SYSTEMSREFRIGERATION SYSTEM ADJUSTMENTSA complete understanding of the Ice Maker and the hermetic refrigeration system is nec

10630460082TEMPERATURE/PRESSURE CHARTREFRIGERANT TYPER404A+ 10 LBDISCHARGE PRESSUREWATER TEMPERATUREAIR TEMPERATURE 40 65 9050– 174 177 18060– 202 205

11 630460082NOTE: Cold water will absorb more heat faster than warm water. The water flow will therefore automati-cally increase as inlet temperature

12630460082THIS PAGE LEFT BLANK INTENTIONALLY

13630460082TROUBLESHOOTINGIMPORTANT: Only qualified personnel should service internal components or electrical wiring.TROUBLESHOOTING GEAR MOTORSBasic

14630460082If no continuity on start or run winding test, replace stator. If continuity on grounded motor test, replace stator.INSTALLATION AND SHAFT

15630460082AUGER & EXTRUDING HEAD REMOVALFIGURE 8. UPPER NUT AND BEARINGThe upper bearings located on top of the auger is used to absorb the force

16630460082C. Voltage – The voltage should be within 10% of the rated nameplate voltage.D. High compressor amperage draw, it should never exceed 120%

i630460082TABLE OF CONTENTSPageSPECIIFICATIONS 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

1763046008210. Check or replace run capacitor (if supplied) check or shorted capacitor or either terminal grounded to case.SAFETY CONTROLSFIGURE 10. G

18630460082GUIDE TO GOOD ICECUSTOMER COMMENTS CHECK ICEMAKER LOCATIONCONDITIONS FIRSTCHECK ICEMAKERIt runs but the ice is too soft.The icemaker is not

19630460082LOW WATER SAFTEYSWITCH OPENICEMAKER RUNS BUTDOES NOT MAKE ICENO POWERSTORAGE CONTAINERBIN SWITCH OPENICEMAKER OPERATING BUT– Soft ice– Poor

20630460082FIGURE 12. WIRING DIAGRAM

216304600826647215969706422236071 5925582659272861581718196720123029676824

226304600823635347281373839404152595032484243444575142114574973765174338682858483888987919093949295

23630460082WM600 AND CM600 ICEMAKERItemNo.Part No. Name1 630000542 Hopper, Cabinet2 164005002 Rivet3 630000520 Rail, Front (Not Shown)4 50806 Gasket,

24630460082WM600 AND CM600 ICEMAKERItemNo.Part No. Name82 638090236 Motor Fan Ass’y, 115V83 638096723 Fan Blade84 638036273 Condenser, Air Cool85 6380

25630460082123456789101112141516FIGURE 13. FRONT END ASSEMBLY EXPLODED VIEW AND PARTS LISTItemNo. Part No. Name1638090050 Gearmotor Assembly, 115V6380

26630460082FIGURE 14. MOUNTING TEMPLATE

ii630460082TABLE OF CONTENTS (cont’d)PageELECTRICAL CHECKOUT 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

27 630460082WARRANTYIMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workmanship un-der normal use and s

IMI CORNELIUS INC.CORPORATE HEADQUARTERS:One Cornelius PlaceAnoka, Minnesota 55303-6234(612) 421-6120(800) 238-3600

1 630460082SAFETY INFORMATIONRecognize Safety InformationThis is the safety-alert symbol. When you see thissymbol on our machine or in this manual, be

2630460082THIS PAGE LEFT BLANK INTENTIONALLY

3 630460082SPECIIFICATIONSModel WM (Wall Model) 600 and CM (Counter Model) 600Compressor 3/4 H.P. (R404 Refrigerant)Vol

46304600823. Apply a continuous bead of NSF listed silastic sealant (Dow 732 or equal) approximately 1/4–inch inside ofthe Unit outline dimensions. Th

5 630460082 INITIAL START UP, CHECKS AND ADJUSTMENT INSTRUCTIONSNOTE: Do not start the Unit before completing the previous Installation steps.Turn on

6630460082GUIDE TO SERVICEIMPORTANT: Prventive maintenance can increase the trouble-free life of your Ice Maker. Failure toperform preventive maintena